Wells WFAE-30F Operations Instructions download pdf (Page 10)

OIL FILTERING INSTRUCTIONS

DANGER

OIL MUST BE FILTERED WHILE HOT (300ºF AND HIGHER)

Contact with hot oil can cause serious injury including death.

Always wear protective clothing and insulated gloves when

filtering the cooking oil.

1. Refer to the Installation, Operation and Maintenance Manual (p/n 301669) for complete operating

instructions for the filter system.

2. The cooking oil must be hot (minimum of 300º F.) in order to filter properly. Cold oil will not flow

through the filter paper. Place the POWER SWITCH to the FILTER position.

3. Insure that the FILTER SCREEN, FILTER PAPER,

and FILTER PAPER HOLDER are properly installed

in the FILTER RESERVOIR. Be sure the FILTER

SCREEN is installed under the FILTER PAPER.

NOTE: If the filter pump is not operating before

the DRAIN VALVE is opened, damage to the

FILTER PAPER will occur, resulting in the oil

flowing but not filtering.

DO NOT run the pump for more than 10 sec.

without oil flowing.

4. Open the DRAIN VALVE. The WOOD DOWEL

may be needed to unplug the drain hole.

5. While draining the oil, pour the FILTER

POWDER into the oil at the point where it

is being drawn down the drain.

6. After all the oil has drained from the

FRYPOT, use the HI-TEMP BRUSH to

push breading crumbs and other debris

down the drain.

NOTE: use caution not to damage the two small CAPILLARY TUBES toward the front of the

HEATING ELEMENT.

7. After 3 - 4 minutes of oil circulation, close the DRAIN VALVE and allow the FRYPOT to fill with the

freshly filtered oil. When all the oil has returned to the FRYPOT, turn OFF the FILTER SWITCH.

Turn the POWER SWITCH to the OFF position until starting to use the fryer again.

7. Allow the FILTER RESERVOIR to cool before servicing. Refer to the IOM Manual (p/n 301669)for

complete FILTER RESERVOIR maintenance instructions.

NOTE: Refrain from using soap in the FRYPOT or FILTER RESERVOIR. Soap residue

will cause the cooking oil to breakdown rapidly.

FILTER

PAPER

HOLDER

FILTER

PAPER

FILTER

SCREEN

(clip inserts into

drain opening)

FILTER

RESERVOIR

“O” RING

1 2 ... 5 6 7 8 9 10 11 12 13 14 15 ... 25 26

Comments to this Manuals

No comments

Wells WFAE-30F Operations Instructions Page 10

Comments to this Manuals

Related products and manuals for Deep fryers Wells WFAE-30F